240v 60v 2500w 200w 30v homemade perman magnet control brushless dc motor for cordless drill
|Certification:CE||Torque:14.81||Usage:Boat, Car, Electric Bicycle, Fan|
|Construction:Permanent Magnet||Continuous Current(A):90.6||Speed(RPM):2580rpm|
VIEW MORE PLS CONTACT US >>>
Q:Motor has been running then fails to start,what to do?A:Likely cause: Fuse or circuit breaker is tripped.
What to do: Replace the fuse or reset the breaker.
Likely cause: Armature is shorted. Motor may make a humming noise and the circuit breaker or fuse will trip. What to do: Disassemble motor and inspect the armature for a burnt coil. Inspect the commutator for burnt bars. If this condition exists, the motor needs to be replaced.
Likely cause: The brushes may be worn down too far and no longer make contact with the commutator. What to do: Check the brushes to make sure that they are still making contact with the commutator. Contact manufacturer for brushes.
Likely cause: Controller may be defective. What to do: Verify voltage is coming out of the controller.
Q: On initial installation, motor fails to start up,what to do?A: Likely cause: Motor is incorrectly wired What to do: Verify that the motor is wired correctly.
Likely cause: No output power from controller. What to do: Measure voltage coming from the controller.
Likely cause: Motor is damaged and the armature is rubbing against the magnets. What to do: Disassemble motor and see if the armature can be realigned by reassembly. Motor may have to be replaced.
Q: Motor takes too long to accelerate,what to do?A: Likely cause: Motor controller not properly set. What to do: Adjust the acceleration trim pot of the controller.
Likely cause: Brushes are worn. What to do: Verify brush length.
Likely cause: Bearings may be defective. What to do: Inspect bearings. Noisy or rough bearings should be replaced.
Q: Motor runs in the wrong direction,what to do?A: Likely cause: Incorrect wiring What to do: Interchange the two motor leads.
Q: Motor runs OK but has a clicking noise,what to do?A: Likely cause: Suspect a burr on the commutator. What to do: Remove burr from commutator using a commutator stone.
Send your message to this supplier
- Ningbo Haofeng Magnet Technology Co., Ltd.
What is this?This feature is Quick question function, select the corresponding question types, automatically enter the corresponding problem, remove your trouble of typing
North America , South America , Eastern Europe , Southeast Asia , Africa , Oceania , Mid East , Eastern Asia , Western Europe , Central America , Northern Europe , Southern Europe
You May Also Like
- OD 63 mm 3800 rpm brushed 12v 24v high speed high torque permanent magnet electric 12 volt dc motor BMM346 USD $12.7 - $20.95 / Piece
- nema 17 high torque planetary gear reduce stepper motor/dc worm gear motor USD $139 - $239 / Piece
- Good quality low cost 24v 400w 3000rpm dc brushless servo motor USD $200 - $690 / Unit
- High Efficiency Powerful 1.2kw 3000rpm brushless waterproof motor for Industrial use USD $60 - $200 / Unit
- High efficiency 12v 60w 120w dc motor brushless for sweeper machine USD $16 - $28 / Piece
- High Speed 2HP 12V Winch Motor DC Hydraulic Motor Price USD $50 - $58 / Piece
- 12v 800w 1500rpm big start torque brushless dc motor USD $200 - $500 / Unit
- DC Planetary Gearbox ETPG31 USD $6.9 - $15 / Piece
- E-6 230v 3000w 3000rpm BLDC temperature sensor boat electric tricycle vehicle brushless motor for lawn mower USD $550 - $550 / Unit
- Factory supply custom 12v 48v 110v 115 volt 230v 310v brushless dc electric motor for automation machine USD $22 - $43 / Piece
- Wholesale 24v 75w 3500rpm brushless electric dc motor price for robot USD $22 - $43 / Piece
- 1 nm 36v 3000 rpm 500w 1800w kipas angin listrik cpu fan brushless dc motor with integra electron USD $200 - $500 / Unit
- electric actuator linear stainless steel waterproof 12v 24v USD $120 - $250 / Piece
- Customized permanent magnet 100w 230v 300v dc brushless motor USD $36 - $58 / Piece
- 500w Hot sale carbon brushes for electric motor USD $20 - $75 / Piece
- IEC standard 63S 3000rpm 200w permanent magnet synchronous brushless DC motor USD $99 - $159 / Unit